Sep 30

Soap Production

Method of production of the soap to the base of leached ashes and oil of coconut on the basis of the experimental study concludes that the soap to the base of leached ashes and oil of coconut can according to be produced following methods: Substances and materials sodium Chloride (NCl) ' ' kitchen salt comum' ' Leached ashes trade bill Oil of coconut Scale precipitation Cup Spatula Stove Forms Pipette Termmetro Test tube Rod Method Procedures 1. To boil at least 80 ml of trade bill until the volume to lower to the half and later cooling in a bath? Maria until the temperature of the trade bill to lower approximately for ambient temperature (25 C); 2. To introduce 8 sodium chloride g in the container to use for the cozedura of substances; 3. To add 2 ml of coconut oil (to melt the oil in case that it is made solid); 4. To introduce 40 ml of trade bill previously concentrated of point 1; 5. To very move the mixture well until the total dissolution of sodium chloride; 6.

To take the mixture to the boil. After about some minutes, it will be able to observe foam formation that will go to raise itself of level and after a time will lower until the o lower level. At this moment, they will appear salpicos, the soap is ready. 7. To remove the container of the source of the heat. To pour the mass in a form.

After one day of the process of cure of the soap already it is in height of being used. Method B Procedures 1. To weigh 8 sodium chloride g and to introduce in the container to use for the cozedura of substances; 2. To add 4 ml of coconut oil (to melt the oil in case that it is made solid); 3. To introduce 40 ml of trade bill; 4. To very move the mixture well until the total dissolution of sodium chloride; 5. To take the mixture to the boil. After about some minutes, it will be able to observe the not consistent foam formation that will lower immediately of level. At this moment to add 40 more ml of trade bill. Later, the foam will appear again, is raised seguidamente of level and low. Finally, they appear salpicos that they indicate that the soap is ready. 7. To remove the container of the source of the heat. To pour the mass in a form. After one day of the process of cure of the soap already it is in height of being used. Note: it will be able to observe in the form (receiving where it goes to pour the mass) a liquid (excess: glycerin and trade bill). To remove the excess before use the soap. In case that it wants raised amounts, it must multiply all 0 variable for factor the same. Precautions: The leached ashes trade bills are products caustics that can burn the skin therefore, must be taken in the process of the production of the soap to the base of leached ashes and oil of coconut very well-taken care of. It must be used adobe or glass containers. Preparation of the trade bill the trade bill is prepared from leached ashes and water in the ratio of 1:2. The maceration process must take the minimum of nine days for form to get trade bill of high concentration of total lcalis.